Welcome to myHanse.com the forum for Hanse Yachts owners throughout the world. | |
Grey water pump |
Post Reply | Page 123 4> |
Author | |
Black Diamond
Vice Admiral Joined: 24 October 2015 Location: Newport, RI, US Status: Offline Points: 923 |
Post Options
Thanks(0)
Posted: 29 June 2018 at 11:33 |
In the time since last August, I've gone thru 2 of the JABSCO 50880 grey water pumps. I've now got 2 spares on the boat, as well as 2 spare water witch switches. Has anyone else gone thru these pumps quickly? We are pretty careful about sink debris getting into the grey water tank. Its not getting clogged. It just stops working and the pump gets very hot as its still drawing power but has apparently seized. I'm wondering if a more rugged unit would be better? We don't live aboard, but use the boat quite a bit and can stay on it for weeks at a time. |
|
Rick
S/V Black Diamond Hanse 575 Build #192, Hull# 161 Newport, RI |
|
Sea-U
Commadore Joined: 14 September 2012 Location: Norway Status: Offline Points: 459 |
Post Options
Thanks(0)
|
I have used this pump for shower drain for 5 years. Over 50 showers a year and no trouble.
|
|
Sea-U is a 370e #532 located SW Norway
|
|
Wayne's World
Admiral Joined: 18 July 2012 Location: Cruising Status: Offline Points: 1111 |
Post Options
Thanks(0)
|
Rick, Our UK warranty dealer - Inspiration Marine Group supplied us with standard float switches instead of the Hanse supplied switches which IMG said were failing and causing the pumps to stay on and seize. We changed the switches over and have not had any problems for 4 years liveaboard. We had one pump fail before we changed the switches over. |
|
Wayne W
Cruising, currently in the Caribbean and will head across the Pacific early 2024 |
|
Black Diamond
Vice Admiral Joined: 24 October 2015 Location: Newport, RI, US Status: Offline Points: 923 |
Post Options
Thanks(0)
|
The switches (Water Witch) are fine. The pump just seizes and gets hot. Twice so far. I have spares and since its a new boat, Hanse and my dealer is covering the cost of the part, but if one more goes bad I may look into alternative pumps. 50 showers on our boat happens in a few weeks, not 5 years.. Between my wife and I, my daughter and her husband, as well as sink and occasional washer/dryer use, these need to be hardy. Are your's 24V or 12V? Maybe a bad run of 12V pumps?
|
|
Rick
S/V Black Diamond Hanse 575 Build #192, Hull# 161 Newport, RI |
|
Relentless
Commander Joined: 17 April 2018 Status: Offline Points: 132 |
Post Options
Thanks(0)
|
I just replaced the foreward pump and I can see the aft pump was replaced by the previous owner.
I took the failed pump apart and found the windings in the motor overheated and shorted. The nameplate on the pump specs to be fused at 10amps but my boat has 30amp fuses in place! Rick, what fuses do you have? |
|
Wayne's World
Admiral Joined: 18 July 2012 Location: Cruising Status: Offline Points: 1111 |
Post Options
Thanks(0)
|
Rob,
We had 15 amp fuses for our shower pumps which I replaced with 10 amp fuses per the pump manufacturers recommendations/directions.
|
|
Wayne W
Cruising, currently in the Caribbean and will head across the Pacific early 2024 |
|
Black Diamond
Vice Admiral Joined: 24 October 2015 Location: Newport, RI, US Status: Offline Points: 923 |
Post Options
Thanks(0)
|
10 amp fuses. I found the wrong fuses used early on and changed them. This isn't a fusing issue in my mind. Its a usage issue. If someone takes a long shower, or if you put a lot of gray water into the tank without giving the pump a "rest" somewhere in there, I find that it shuts down for heat reasons and then will eventually restart. Over time, I think this problem eventually fries the pump. Not sure if its hardy enough for the job. Edited by Black Diamond - 10 August 2018 at 01:12 |
|
Rick
S/V Black Diamond Hanse 575 Build #192, Hull# 161 Newport, RI |
|
marcopone
Commander Joined: 24 April 2013 Location: Italy Status: Offline Points: 137 |
Post Options
Thanks(0)
|
Very strange.
On my H575 I modified the installation of the pump in the owner’s cabin. Often it was not priming, it was sucking air from the tank and could not pass it through. Because of this it was running idle for long time. I also modified the level switch so that some water remain on the bottom of the tank. For the aft pump I installed a plastic pipe from the tank to the motor space to take out air. I noted that sometime the water from shower was not going in the tank because air could not escape from tank. |
|
Black Diamond
Vice Admiral Joined: 24 October 2015 Location: Newport, RI, US Status: Offline Points: 923 |
Post Options
Thanks(0)
|
Its interesting. The aft grey water box has only had to have its switch replaced (water witch), but twice. The forward grey water box on our boat has been replaced twice, but the same switch is still there. As my wife and I are on the boat a lot, the forward one sees our showers as well as the galley and forward sink usage. The aft one sees the dishwasher and the washing machine use, but also showers and aft sink when our daughter and her husband come to visit. Its more annoying than problematic. I still think its not robust enough for the job, but I cannot seem to find an easy replacement that would be an upgrade from what is there. |
|
Rick
S/V Black Diamond Hanse 575 Build #192, Hull# 161 Newport, RI |
|
boomjack
Captain Joined: 24 August 2014 Location: switzerland Status: Offline Points: 173 |
Post Options
Thanks(0)
|
On my side, I had this problem the first year and replaced the pump once, then I had it a second time and replaced again the pump, but this time I installed a different switch inside which authorize the pump to work only when the tank is effectively full of water. For me the problem was that with soap and sun cream residus, the contact with the previous swicth was permanent conducting the pump to work continuously and overheating before dying. Since this modification it works perfectly.
|
|
Post Reply | Page 123 4> |
Tweet |
Forum Jump | Forum Permissions You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |
Links : www.hanseyachts.co.uk www.hanseyachts.com www.fjordboats.co.uk www.dehler.co.uk www.varianta.co.uk |