Welcome to myHanse.com the forum for Hanse Yachts owners throughout the world. | |
Voltage at propane tank solenoid |
Post Reply |
Author | |
mopoulter
Captain Joined: 19 March 2009 Location: London, Canada Status: Offline Points: 320 |
Post Options
Thanks(0)
Posted: 04 July 2017 at 18:48 |
My Propane shut off switch is not working. The switch may be faulty but when I was testing the connections I found that there was only 11 volts between the hot end and the ground of the fuse.
(by passing the switch). 11 volts seems weird to me batteries are fully charged and volt meter says 14 volts or so when charging. and about 12.8 to 13.5 when charger is off. Any one have an idea where 1.8 volts is disappearing? |
|
mp
Hanse 370 #416 "Anxiolytic" |
|
High Time
Vice Admiral Joined: 04 September 2012 Location: Portsmouth UK Status: Offline Points: 798 |
Post Options
Thanks(0)
|
Is the shut-off solenoid (presumably) part of an automatic gas detection alarm system or simply wired to an on/off switch that you operate manually?
If part of a gas alarm system the voltage may be regulated within the sensor/alarm unit. Alternatively, it's also possible that the solenoid draws several amps in the open state which could cause 1.8V drop if the wiring/connections are not properly sized for that sort of current.
Edited by High Time - 04 July 2017 at 19:24 |
|
Roger
High Time (415 #038) |
|
mopoulter
Captain Joined: 19 March 2009 Location: London, Canada Status: Offline Points: 320 |
Post Options
Thanks(0)
|
No there is no gas alarm system.
There is simply a on/off switch that opens the solenoid. It was functioning until a week ago when it stopped. My examination of the voltage between hot end and ground was when I read the 11 volts, jumping across the switch does not open the valve but the connection is poor. I have ordered a new switch perhaps this will solve things. Also I can't imagine that the switch would dram large amount of amps. Thanks for your suggestions |
|
mp
Hanse 370 #416 "Anxiolytic" |
|
Jens
Lieutenant Commander Joined: 31 August 2007 Location: Denmark Status: Offline Points: 79 |
Post Options
Thanks(0)
|
I had problems with my fridge some time ago. The light was working, but
when compressor tried to start voltage dropped down – and light went out. I
found out that there is a connector close to the compressor and this was
completely corroded. Problem was that the connector was lying on the boat
bottom below the compressor where it occasionally got in contact with water.
Maybe the cable to your propane solenoid is also under the floor. In case the
switch does not fix the problem, it would be a good idea to try with a + and –
cable directly from the battery. Jens |
|
Jens
Hanse 370, #423, 2008 Three cabin |
|
mopoulter
Captain Joined: 19 March 2009 Location: London, Canada Status: Offline Points: 320 |
Post Options
Thanks(0)
|
Spent most of Friday trying to trace wire, found it disappearing under cabinets next to stove!!! Thought Ok will need to run a new line or pull cabinets! Later a friend who is a millwright looked at problem, he actually used to fix robots on an auto assembly line so he knows his stuff. He looked and found the inscrutable 10-11 volts as well even when we grounded to ground wire on throughhull. He could not understand it either. So he suggested just for "smiles and giggles" lets hook up the whole system as if nothing was wrong and cut the wires at the solenoid to see what voltage is there. There was 12.8 volts????!!!!! So then we pulled the solenoid and it was seized. So I have new one on order. Go figure??? So I started at the wrong end of the system and was lead down the garden path by some wiring anomaly that perhaps only Hanse can explain.
|
|
mp
Hanse 370 #416 "Anxiolytic" |
|
mopoulter
Captain Joined: 19 March 2009 Location: London, Canada Status: Offline Points: 320 |
Post Options
Thanks(0)
|
So to end the story. The replacement of solenoid was no help. So we re-wired then entire switch and still had 10.8 volts even when we ran a ground to the ground plates in hull. We dropped the circuit breaker panel and traced the power line of the switch in galley to the panel. Imagine our faces when we found there in the line was a two amp fuse !!! We wiggled the fuse and the voltage fluctuated between 10.8 and 13.0 volts!!! We secured the fuse with some electrical tape and voila! problem solved. Why the f*&k would there be a two amp fuse in the power line to the solenoid switch? The fuse at the switch is 5 amps!!! so the 2 amp fuse would blow before the 5 amp fuse ???
Sometimes I wonder about the "professionals" that install stuff on our boats. |
|
mp
Hanse 370 #416 "Anxiolytic" |
|
Aeolian
Sub Lieutenant Joined: 05 November 2020 Location: Seattle WA Status: Offline Points: 9 |
Post Options
Thanks(0)
|
I am having same issue I believe... been tracing problem and the only thing that makes sense is a mystery fuse in line I can't find. Any advice on where you found this 2 amp fuse?
Best, Equally confused owner
|
|
Jared Rodgers
Seattle, WA Hanse 458 - Aeolian |
|
415 Singapore
Vice Admiral Joined: 23 September 2013 Location: Singapore Status: Offline Points: 826 |
Post Options
Thanks(0)
|
Call me old fashioned, but what is wrong with a manual stopcock? The idea of having something electrical on a gas line doesn’t sound good.
On Night Train, we have a stopcock under the stove and one on the gas bottle. Or am I missing the point? All the best Paul
|
|
Paul - Night Train - 415 #136
|
|
alettaenmarcel
Admiral Joined: 15 August 2006 Location: Netherlands Status: Offline Points: 1218 |
Post Options
Thanks(0)
|
Same at my 370 Kis …..”keep it simple “ and it will always work
|
|
Kids Dingys 72-79 ,Several Windsurfboards 79-86 OK dingy competitions 86-92 , Trotter Pandora Race 92-98, Friendship 28 Sport 98-05, Hanse 370 06-......
|
|
Post Reply | |
Tweet |
Forum Jump | Forum Permissions You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |
Links : www.hanseyachts.co.uk www.hanseyachts.com www.fjordboats.co.uk www.dehler.co.uk www.varianta.co.uk |